The lubricity performance of hura crepitans and calophyllum inophyllum plant oil in water-based mud in analysing differential pipe sticking

This study applied diesel oil, and oil from two non-edible plant seeds which are Hura crepitans and Calophyllum inophyllum. These non-edible oils were extracted from their seeds using the soxhlet extractor and used in the oil-in-water emulsion mud. | The lubricity performance of hura crepitans and calophyllum inophyllum plant oil in water-based mud in analysing differential pipe sticking International Journal of Mechanical Engineering and Technology IJMET Volume 10 Issue 03 March 2019 pp. 364 379 Article ID IJMET_10_03_037 Available online at http ijmet JType IJMET amp VType 10 amp IType 3 ISSN Print 0976-6340 and ISSN Online 0976-6359 IAEME Publication Scopus Indexed THE LUBRICITY PERFORMANCE OF HURA CREPITANS AND CALOPHYLLUM INOPHYLLUM PLANT OIL IN WATER-BASED MUD IN ANALYSING DIFFERENTIAL PIPE STICKING Onuh C. Y. Dosunmu A. Anawe P. A. L. Agbator S. Department of Petroleum Engineering Covenant University Ota Nigeria Ojonimi I. T. Seteyeobot I. Department of Mining Engineering University of Jos Nigeria. ABSTRACT This study applied diesel oil and oil from two non-edible plant seeds which are Hura crepitans and Calophyllum inophyllum. These non-edible oils were extracted from their seeds using the soxhlet extractor and used in the oil-in-water emulsion mud. Mud lubricity tester was used to determine the torque coefficient of friction and mud lubricity coefficients were calculated at different revolutions per minute and concentrations of the oil. The rheological properties of the mud were also tested. The results obtained from the experiment showed that Hura crepitans in water-based mud have the highest mud lubricity coefficient and next is oil from Calophyllum inophyllum. It was also discovered that diesel oil in the water-based mud has a negative effect on the coefficient of friction the mud formulated with the plant oils has the lowest volume of fluid loss when compared to ordinary water-based mud and that of the diesel oil. The mud formulated with oil from Hura crepitans has relatively higher plastic viscosity most especially at concentrations above 15 ml and the addition of Calophyllum inophyllum has the highest yield point values and gel strength. The plant oils most especially .

Không thể tạo bản xem trước, hãy bấm tải xuống
TÀI LIỆU MỚI ĐĂNG
Đã phát hiện trình chặn quảng cáo AdBlock
Trang web này phụ thuộc vào doanh thu từ số lần hiển thị quảng cáo để tồn tại. Vui lòng tắt trình chặn quảng cáo của bạn hoặc tạm dừng tính năng chặn quảng cáo cho trang web này.